image
GET A QUOTE

Naples Heritage Pump House

Location: Naples, Florida

Facility: Irrigation Pump House

Construction Type: Pump Station Replacement — Structural Wall Modification

Project Description

At Naples Heritage, the irrigation pump station had reached the end of its service life and needed to be replaced. The obstacle wasn’t the equipment itself — it was getting the old station out and the new one in. The pump house had been built around the original station, and the only designed access point, the roof hatch, was far too small to remove the old unit or bring in the replacement.
Contact Us
The Naples Heritage pump house with a section of block wall removed and shoring posts in place, exposing the old irrigation pump station inside for removal.

Naples Heritage Pump House Photos

Exterior of the tile-roofed Naples Heritage pump house with a large opening cut into the block wall and steel rails staged to move the irrigation station.
Wide exterior view of the Naples Heritage pump house during the wall opening, with the work zone, water tank, and staging equipment around the building.
A crane boom positioned at the Naples Heritage pump house wall opening with a steel support beam spanning the gap as the new irrigation station is moved into place.
The new irrigation pump station installed inside the Naples Heritage pump house, with a steel support beam spanning the wall opening before the wall was rebuilt.
The new irrigation pump station set in place inside the Naples Heritage pump house, with the structural header beam overhead and block wall rebuild beginning.
Interior of the Naples Heritage pump house showing the new irrigation pump station with its control cabinet and green discharge piping installed and operational.
Fresh cinder block staged at the Naples Heritage pump house as the removed wall section is rebuilt beside the louvered vent and finished wall.
The rebuilt and refinished exterior wall of the Naples Heritage pump house, re-stuccoed and painted to match the existing structure with no sign of the opening.

Our assessment revealed the key challenges of the replacement:

contact us
CreekIcon2
Roof hatch too small — no usable access route for the old or new station
ccIcon3
Old station out, new station in — without damaging the building
mmIcon1
Load-bearing wall required temporary support while open
mmIcon
Wall rebuilt and refinished to match the original structure
Rather than force the equipment through an opening that would never fit, Roughneck Ranch created a temporary access route by removing a section of the block wall. With the wall opened and the structure properly supported, the team pulled the old irrigation station out, slid the new station into place, and then rebuilt and refinished the wall to match the original structure.
A crane boom positioned at the Naples Heritage pump house wall opening with a steel support beam spanning the gap as the new irrigation station is moved into place.
The rebuilt and refinished exterior wall of the Naples Heritage pump house, re-stuccoed and painted to match the existing structure with no sign of the opening.
The completed repair blends cleanly into the existing structure, leaving no sign of the opening that made the entire replacement possible.
This project highlights Roughneck Ranch’s problem-solving approach to facility work — finding the most practical path to a difficult goal and executing it without compromising the building. By thinking through the access challenge up front and supporting the structure properly throughout, the team delivered a clean irrigation pump station replacement and restored the pump house to its original condition.

Frequently Asked Questions

contact us
What services does Roughneck Ranch offer?

End-to-end golf course maintenance facility construction across Florida, including complete facility builds, concrete, custom steel buildings, wash racks, cart storage, pump houses, and licensed electrical and plumbing.

Based in West Palm Beach, FL, serving golf courses throughout the state.

Family-owned and licensed, specializing exclusively in golf course maintenance facilities with in-house construction, electrical, and plumbing — so one team handles the entire project.

Yes — projects of all sizes, from new construction to renovations and structural upgrades.

Wash stations, chemical mixing areas, and full-system designs built for the demands of golf course maintenance operations.

Contact Us Today to discuss your golf course facility needs.

Contact Andy Now!

Request a
Free Quote Contact Us Now

Choose us for quality craftsmanship, timely delivery, and a seamless experience. We bring your vision to life with expertise and excellence.

Services

Contact Us

image17

Connect With Us!

Facebook Instagram Linkedin-in

© Roughneck Ranch. 2025 All Rights Reserved

image17